Tyre Sealant And Puncture Prevention

Mod Description

Not having a spare tyre can be a concern to some people but there are products that stop a puncture as it happens or cheaper versions that stop you being stranded by the side of the road.

Mod Details

PremiumNo Difficulty Mod ID565 CreditEvilution Cost££5 - £40 For Linkhttps://dev.evilution.co.uk/mod/tyre-sealant-and-puncture-prevention.htm Copy to Clipboard

Tyre sealants come in 2 catagories,

Use after the puncture.
Use before the puncture,

Each type has their own pros, cons and rules to follow.

Use After The Puncture Has Occured

These can be bought from motor shops like Halfords for as little as £5, the small size cans allow them to be stored under the seat etc until they are needed.

2 common makes are Tyreweld and Fix-A-Flat, both very similar to each other.

Application

As soon as you realise you have a puncture you should stop the car and jack up the wheel if possible. Read the can and it will tell you the amount required although it’s hard to determine how much you have used. The tyre should then be pumped up to the correct pressure before you continue driving.

Pros

Cheap
Small
Easy to use

Cons

Limited to driving 50 miles on the repaired tyre
Limited to 50mph
Tyre cannot be repaired
Hit and miss sucess rate
Tyre wall could be damaged from running flat

Smart’s Option

The smart can come with its own solution which stores nicely in the footwell block. The drawback is the price compared to all the other solutions. You get a valve remover, bottle of tyre sealant with a straw..

…and a compressor to reinflate the tyre.

Shieldwell & Slime

There are a few other products out there that can be added to the tyre to repair punctures as they happen of they can be added to repair a recently caused puncture. Products like Shieldwell and Slime are ok in the smart to repair punctures but they should not be preinstalled as they have limited speed and/or distance on the repairs.

Unlike Tyreweld and Fix-a-flat, these products aren’t as easy to fit yet are still classed as a temporary repair. You can still only do a maximum of 60mph and depending on the product you may be limited to how far you can travel once the product is used. If you don’t know you have had a puncture repaired because the product was preinstalled you will not know that you shouldn’t exceed 60mph.

Use Before The Puncture Has Occured

These products are injected into the tyre and will seal any punctures as they happen. Because they are pre-fitted to the car there is no need to carry the product around. It also means that you won’t be trying to do it late at night on the side of a road.

After a bit of research, the only product that falls into this category is Ultraseal. There are ultraseal franchises everywhere that will fit it for you or you can buy a kit yourself.

Application

One wheel at a time should be jacked up and the valve removed, read the instructions and determine how much you should put in. Screw the container to the stem and add the correct amount. Disconnect the container and replace the valve, inflate the tyre to the correct pressure. Repeat with the other wheels.

Pros

Install it when you want to
You don’t have to carry the stuff around
Repairs the tyre without losing pressure
Unlimited driving speed and distance
Can be washed out for a repair

Cons

More expensive
Can cause unbalanced wheels for a few miles

Other Info

Ultraseal is safe to use with the tire pressure monitoring system found on American smarts.

Ultraseal also make combat formula ultraseal for the army, an army HUMMV tyre survived a shot through the sidewall with a 7.62 round. The round went in 1 tyre wall and out the other, both holes self healed immediately and the tyre lost almost no pressure.

And The Winner Is?

You! obviously, imagine not having to worry about punctures. Ultraseal has everything covered for less than the cost of a new tyre, for this price you are protecting all 4 of your tyres. It is a permanent repair so it’s fit and forget. If you want Ultraseal fitting to your car, go to Google and type in Ultraseal. You will be given a list of all the franchised fitters, you just have to find your local fitter.